Payment & Shipping Terms:
|Wall Panel:||EPS||Internal Size:||12x4.5x4m|
|Fan:||7.5KW Turbo Fan||Heating:||Riello G20 Diesel Burner|
|Draft Type:||Down Draft From Pit In The Ground||Light:||LED|
truck paint booth,
automotive spray booth
Commercial Downdraft Truck Spray Booth Coating EPS Wall Panel Eco Friendly
1. 0.476mm color steel with EPS inside for wall panel.
2. Quality brand name turbo fan,with air capacity of 25000m ³/h
3. Pneumatic damper for spraying to baking cycle.
4. All panels are tongue and groove interlock structure
5. Control panel and other electric components can be purchased separately
In painting, outside fresh air comes into the heating generators through the pre-filter system, and enters into the plenum, then filtered by ceiling filter and into the both which brings clean,
symmetrical and steady-going down airflow for spraying. After painting, Hot air goes from heating
generators to plenum, then enters room after filtered by ceiling filter, providing heat that is necessary for baking of cars surface. Afterwards, the air with little benzene will be released to the atmosphere after being filtered twice by the exhaust air filter
|Inside dimension||12000×4500×4000 mm (L×W×H)|
|Outside dimension||12144×6046×4600 mm (L×W×H)|
|Front door (3sets)||Folding door, 3 sets, on the front, middle and back side, 3000×3500 mm (W×H), galvanized steel frame, blue color.|
|Emergency door||2 units, 800×2000mm (W×H), colour: white.|
|Basement||Without basement, exhaust from pits, size of each 4600×760 mm (L×W)|
|Wall panel||Thickness: 70mm, width: 1150mm, tongue and groove structure, 0.426mm colour steel with EPS insulation inside, colour: white.|
|Light||Ceiling Lights: 16Units×4Pcs=64Pcs×36W, side light: 12Units×2Pcs=24Pcs×36W, with electronic ballast, lighting box are powered coated.|
|Generator cabinet||Intake from side upper, exhaust from rear upper, quadrate steel frame; white coated steel outside
covered, galvanized steel inside, filled with heat preservation material in the middle.
|Intake and Exhaust system||Inlet: 2 units, in total 2×7.5KW turbo fans, air capacity for each fan: 25000m /h.|
|Outlet: 2 units, in total 2×7.5KW turbo fans, air capacity for each fan: 25000m /h.|
|Heating system||2 units RIELLO G20 diesel burners, stainless steel heat exchanger, pneumatic damper actuates
from spraying to baking cycle. Max. heating productivity: 200000kcal/h, maximum temperature:
|Purification system||Pre-filter, ceiling filter, fibreglass filter, activated carbon filter.|
|Roof||Galvanized steel panel.|
|Control system||Spraying, heat spraying, baking, time setting, lighting switch, failure indicator, thermostat, power
supply switch, emergency stop, hours meter, temperature limit controller, pressure gauge, all motors are normal start.
|Total power||34KW(powder supply:1×220V, 3×380V,50HZ)|